Top 7 Steps for Winterizing your RV Plumbing System

Top 7 Steps for Winterizing your RV Plumbing System

 

Mark Polk, motorhome maintenance expertBy Mark Polk
RV Education 101

It’s always sad to come to the realization that another camping season is winding down.  Depending on where you live, part of this realization is preparing the motorhome for winter storage so it will be ready to go camping again next spring.

A major part of winterizing your motorhome is to protect the RV water system from potential damage caused by exposure to freezing temperatures. Frozen and damaged water lines are the most common problems related to not winterizing your RV, or not properly winterizing your RV.

The RV plumbing system is the system that is most vulnerable to damage caused by plummeting temperatures. The good news: It’s easy to protect the RV water system from this potential threat. Here are my top 7 Steps for Winterizing your RV Plumbing System.

Before you get started, here are some items you will need. These items can be found in most RV parts stores:

  • Non-toxic RV/Marine antifreeze. The amount depends on the layout and length of your plumbing lines. Two to three gallons will normally do.
  • A water heater bypass kit, if not already installed.
  • A wand to clean out the black-water holding tank, if the motorhome doesn’t have a built-in cleanout system.
  • A water pump converter kit, or tubing to connect to the inlet side of the water pump.
  • Basic hand tools to remove and install drain plugs.

Note: Be sure to read your owner’s manuals for unit-specific winterizing guidelines. Follow the steps below that apply to your RV.

Step 1:  If you have any inline water filters, remove and bypass before starting. Drain the fresh-water holding tank. Drain and flush the gray- and black-water holding tanks. If the RV doesn’t have a built-in flushing system, clean the black tank out with a wand. Drain the water heater. Open the pressure relief valve and remove the drain plug.

CAUTION:  Never drain the water heater when it’s hot or under pressure. With no water hooked up to the RV and the water pump off, open a hot-water faucet to remove any pressure on the system. Allow the tank to cool before draining.

Step 2: Open all hot and cold faucets; don’t forget the toilet valve and outside shower. Locate and open the low point water drain lines. Use the water pump to help force most of the water out of the system, but turn it off as soon as the system is drained, to prevent damaging the pump. Recap all drains and close all faucets.

Step 3: Bypass the water heater. If you do not have a bypass kit installed, the water heater will fill up with RV antifreeze before it goes through the water lines, wasting 6 or 10 gallons of antifreeze.

Step 4: Install a water pump converter kit, or disconnect the inlet side of the water pump (the line coming from the fresh-water holding tank) and connect tubing from the water pump inlet into a 1-gallon jug of RV antifreeze.

Step 5: Turn the water pump on and pressurize the system. Starting with the closest faucet to the pump, slowly open the hot and then cold valves until the red-colored RV antifreeze appears. Replace the antifreeze container as required. Repeat on all faucets from the closest to the farthest away. Don’t forget the outside shower.

Step 6: Flush the toilet until antifreeze appears. Pour a cupful of antifreeze down each drain. Pour some RV antifreeze in the toilet and flush it into the holding tank to prevent any water in the tank from freezing. If your water heater has an electric heating element, turn it off. This will protect the element if the unit is plugged in while in storage. Make sure all faucets are closed.

Step 7: Consult your owner’s manuals for winterizing ice makers and washing machines.

The RV is winterized. Now, next spring when it’s time to head out in the motorhome you won’t have any unpleasant, not to mention costly, surprises waiting for you.

Happy Camping.

Advertisements

About smokeycamping

Well let's see have lived in NY for my whole life, have always loved the outdoors (as long as it is warm out) have always hated the cold, and like a dummy have stayed in NY. But now with my second try my wife, we have been camping now for well over 25 yrs. We currently own a 2010 Cedar creek silverback 35TS and can not wait to get out on the highways and see this great country we all call home. Hope to see every National park before my medical issue becomes too bad to travel. I love my African gray parrot (she is my baby) and have two dogs at the time brother and sister mutts, but love them all the same. Have always been a big Nascar fan, love computers (have a number of certificates to build and work on them) am trying to learn photography, enjoy light hiking, being with good friends and folks. country music, pop music and just being outdoors. So I hope someday to meet some of the great people who like what I like and post out there in some great campground somewhere in the country, till then I will keep posting and I hope you keep liking.

Posted on October 4, 2014, in The world as i see it as a camper and who loves his country and tagged , , , , , , , , , , , , , , , . Bookmark the permalink. Leave a comment.

Leave a Reply

Please log in using one of these methods to post your comment:

WordPress.com Logo

You are commenting using your WordPress.com account. Log Out / Change )

Twitter picture

You are commenting using your Twitter account. Log Out / Change )

Facebook photo

You are commenting using your Facebook account. Log Out / Change )

Google+ photo

You are commenting using your Google+ account. Log Out / Change )

Connecting to %s

%d bloggers like this: